Products

Clean environment · Clean life

Your Position:Home > Products > Micro Glassfiber Filter Media > Oil and Air Separation Media
Oil and Gas Separation Glass Fiber Filtration Media

GLASS FIBER OIL &SEPARATOR MEDIA

In the compressor system, the oil itself must be filtered on a regular cycle so as to remove contaminants that may enter the compressor and damage the unit. This is accomplished through the installa-tion of a lube oil filter, either in cartridge, or spin-on form, which then ensures that all of the oil is cleaned as it moves through the filter

filtering in 5-20 micron range (depending upon application), it is again, the deposit-ing of oil-borne contaminant over time (similar to the oil-separator), that causes the oil filter to continually increase in differential pressure to a point at which it must be replaced in order to continue proper filtration of the compressor oil

ZJ Filter Media offers complete solutions for both Primary and Secondary  filtration stage.


Raw material: Micro glass fiber and Synthetic  

      Advantage

Oil Saparator Ad.jpg

Advanced production processing technology :

Ultra-low concentration primary forming process

Patented hot air drying technology

Quality Control System   

        DCS Operate system   

Online monitoring system 

Defect identification system  

Application: 
oil air separator.jpg

      Compressor Filtration


 Oil and Air Separator   Media Data  
Model No Grammage  g/m2 Thickness   (mm) Air   Pemeability  CFM Air   flow resistance mm/H2O DOP   smoke penetration Max   Pore  um Stiffness  mg  tensile strength MD  kn/m Tensile   strength CD kn/m
ZJ08525 85 0.45 14 10 18 25±3 1500 1.2 0.5
ZJ08535 85 0.5 24 7 40 35±3 1500 1.2 0.5
ZJ08599 85 0.45 14 10 18 25±3 1500 2 0.6
Raw Material: Micro   fiber glass 
1.Test under   Pressure 50KPA
2.Air resistance   and filtration efficiency tested by: TDA- - 100P (0.3 μm, 5.3cm/sec) ATI   company
3.Air permeability   tested by: LabAir IV FX3300(Area: 38 cm2 pressure: 125pa)
4.The above are the   average data obtained in the production process The actual filter performance   will vary
according to   the  filter design parameters.There are   also variations due to the technical parameters tolerance.
We always try   improving our products, so we reserve the possibility to change the technical   parameters
Related Products
CopyRight © 2018 Hunan Zhengjia Special Materials Co., Ltd.. All Rights Reserved
粤ICP备14001694号-由万创科技提供技术支持
Address: Economic Development Zone, Qimenqiao Town, Shuangfeng County, Loudi City, Hunan Province Tel:0755-8955673